If it's a head gasket leak can it be changed without pulling the motor?

Asked by Guru6Y4Y7 Mar 12, 2020 at 10:13 PM about the 1999 Subaru Legacy Outback Limited 30th Anniversary Wagon AWD

Question type: Maintenance & Repair

It overheats after a few minutes of driving. It can
sit and idle seemingly for as long as I want it to
without overheating.  I tried to bleed the air out of
the cooling system because I new that it was
recently serviced.  But the bubbling (more rapid
and larger bubbles than any video I've seen) never
stops. After a short drive a mile or so the top
radiator hose comes off the the radiator.  The top
hose is always hot as it should be and the bottom
is always cold. So I was hoping I just needed a new
thermostat.  Well I replaced that and then k get the
same problem of overheating after a short drive. Is
it definitely a head gasket leak and can the gaskets
be changed without pulling the engine??

3 Answers

Probably can be done with the engine in the car but not a good job.

1 people found this helpful.
101,595

You can confirm it is a head gasket with a BlockTester kit, since it's obviously affecting the coolant. A lot of motors these days are dropped from underneath along with the sub frame, rather than pulled from the top. But to do a big job like this the front of the motor needs to come apart as well as the heads, and to leave motor in your still taking apart practically the entire front clip to get to all that. Talk to a Subaru mechanic or a dedicated Subaru forum and see what's involved. I think most shops would prefer to leave motor in place for just head gaskets. Depends to on how much wear is on engine, piston blow by or worn bearings would necessitate a full rebuild anyhow.

1 people found this helpful.

To properly prep the surfaces you really should pull the engine. You also need to send out the heads to be inspected for crack and warp.

1 people found this helpful.

Your Answer:

Legacy

Looking for a Used Legacy in your area?

CarGurus has 222 nationwide Legacy listings starting at $3,200.

Postal Code:

CarGurus Experts

  • #1
    TheSubaruGuruBoston
    Reputation
    2,780
  • #2
    Anthony_60
    Reputation
    1,800
  • #3
    Tom Hawkins
    Reputation
    1,500
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Subaru Impreza
35 Great Deals out of 646 listings starting at $4,299
Used Subaru Outback
39 Great Deals out of 1,142 listings starting at $3,800
Used Toyota Camry
47 Great Deals out of 1,118 listings starting at $2,500
Used Honda Accord
47 Great Deals out of 974 listings starting at $2,995
Used Honda Civic
188 Great Deals out of 3,999 listings starting at $440
Used Subaru Forester
35 Great Deals out of 1,359 listings starting at $3,995
Used Subaru WRX
21 Great Deals out of 434 listings starting at $10,995
Used Toyota Corolla
132 Great Deals out of 2,268 listings starting at $103
Used Nissan Altima
28 Great Deals out of 677 listings starting at $3,795
Used Toyota RAV4
140 Great Deals out of 3,035 listings starting at $3,900
Used Toyota Tacoma
43 Great Deals out of 741 listings starting at $9,975

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.