Cooiling Fan and Heater

225

Asked by Death_by_VW Dec 26, 2011 at 11:44 PM about the 1995 Volkswagen Jetta GLS

Question type: Maintenance & Repair

Background: I had no heat in my Jetta. but the temperature was running normal, right at 200
F. It did take what seemed like forever to warm up so I replaced my thermostat. Upon
replacing my thermostat i still had no heat, and I found a leak at my water outlet. I replaced the
"O" ring on the water outlet and also on the 2 sensors attached. I also had a oil leak at the
valve cover i repaired as well. Leaks solved. After refilling the fluid, I still had no heat. It
appeared my water pump was now not functioning (I am getting frustrated at this point). I
decided if i was going to replace my water pump I would also replace my timing belt i have
150K miles on the car so it was well overdue. After replacing all of thes items. I get it all
together and my Upper and lower hoses have sprung leaks, not bad leaks but leaks none the
less, and I still have no heat. since the leaks were very minor I did not believe they could be
causeing my heat to not work so the only thing left in my eyes was the dreaded heater core.
Reluctant, i replaced the heater core, and both the upper and the lower radiator hoses. Finally,
no leaks. I bleed the coolant system by idling the car with the cap of, slowing adding coolant
as needed. squeezing this hose and that until i ceased to see bubbles. The care was
operating at normal temperature.  I shut it off allowed it to cool, topped of the coolant again.
then took it for a spin around the block. NOW its overheating i assume because the coolant
fan isn't kicking on. I have run a res of wires from the battery to the fan and the fan works....I
am frustrated an I think I am overlooking the obvious can anyone help...ps I still have no
heat.also......

4 Answers

225

Well, since no one answered, here was the fix. Patience It was air-locked. I had some air in both the heater core as well as the radiator. When feeling the lower radiator hose it was cool as was the output of the heater core while the upper radiator hose and input to heater core were very hot. Air could not pass. I ran the car with cap off coolant tank. Using a broom stick, I pushed on the lower radiator hose slowly pushing in an holding the rapidly releaseing. I also messaged the output hose on the heater core and 45 minutes later, air gone, and hot hot heat! No temperature problems at all, i took a long drive and no issues with temperature or heat. My radiator fan still isnt kicking though, but i am not sure at what temperature it is supposed to activate, it could be that it just isnt getting to that temperature.

22 people found this helpful.
245

Thank you for posting! I just replaced my water pump and I have no heat also. So when the sun comes out I'll get in there and do what you said with the hoses. I did that same thing to the hoses to get the fluids through, but it just got colder and it's now snowing out. I have a short in my turn signals too. Keep replacing fuses.. another day

1 people found this helpful.
10

@ death by vw..... . Thanks, answer I needed.

1 people found this helpful.
25

If you are getting foam out of you vents then the air is mixing. It has nothing to do with the core. The vents cover holes in the air distribution. The foam breaks down on the air diverters and then the air mixes!

2 people found this helpful.

Your Answer:

Jetta

Looking for a Used Jetta in your area?

CarGurus has 1,946 nationwide Jetta listings starting at $2,495.

Postal Code:

CarGurus Experts

  • #1
    Deathjam4
    Reputation
    12,330
  • #2
    Goodwrench707
    Reputation
    5,400
  • #3
    Ed92626
    Reputation
    4,630
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Volkswagen Passat
17 Great Deals out of 502 listings starting at $3,500
Used Honda Civic
190 Great Deals out of 4,208 listings starting at $2,916
Used Honda Accord
59 Great Deals out of 1,026 listings starting at $2,995
Used Toyota Camry
44 Great Deals out of 1,140 listings starting at $3,900
Used Volkswagen Golf
39 Great Deals out of 551 listings starting at $4,495
Used Toyota Corolla
137 Great Deals out of 2,258 listings starting at $3,495
Used Hyundai Elantra
143 Great Deals out of 3,056 listings starting at $3,300
Used Nissan Altima
32 Great Deals out of 714 listings starting at $654
Used Volkswagen Golf GTI
23 Great Deals out of 593 listings starting at $6,898
Used BMW 3 Series
66 Great Deals out of 1,237 listings starting at $3,995

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.